任鹏,刘绍根,戴起会,徐锐.IC厌氧反应器+SBAR好氧反应器工艺针对白酒酿造废水处理工艺中试试验运行报告[J].安徽建筑大学学报,2014,22(2):101-106 |
IC厌氧反应器+SBAR好氧反应器工艺针对白酒酿造废水处理工艺中试试验运行报告 |
IC anaerobic reactor + SBAR aerobic reactor process for liquor brewing wastewater treatment pilot test run reports |
|
DOI:10.11921/j.issn.2095-8382.20140223 |
中文关键词: IC反应器 SBAR好氧反应器 酿酒出水 中试规模 |
英文关键词: internal circulation reactor,SBAR aerobic reactor,brewery wastewater,pilot experiments |
基金项目:国家自然科学基金项目(No.2009ZX07210-003) |
|
摘要点击次数: 7012 |
全文下载次数: 0 |
中文摘要: |
试验采用实验室装置和现场中试装置以阜阳金种子酒厂废水为进水,采用IC厌氧反应器+SBAR反应器中试处理工艺,IC厌氧反应器的进水COD和NH4+-N浓度分别为30000mg/L和160mg/L,出水浓度COD和NH4+-N达到1000mg/L和70mg/L左右,一、二级IC厌氧反应器COD去除率分别达到85%、75%以上,NH4+-N去除率分别在22%、17%左右;SBAR反应器的水力停留时间是480 min ,COD容积负荷达到4.0 Kg COD/(m3d),出水COD、NH4+-N去除率分别稳定达到在92%、79%以上,出水pH值在7.0以上。该工艺处理最终出水COD和NH4+-N浓度则分别低于100mg/L、10mg/L。出水均达到《发酵酒精和白酒工业水污染排放标准》(GB27631-2011) |
英文摘要: |
the laboratory’s test and field test devices choose Fuyang golden seed winery wastewater as influent, the test process is IC anaerobic reactor +SBAR reactor, the concentration of influent COD and NH4+-N in IC anaerobic reactor were 30000mg/L and 160mg/L, and the effluent concentration were respectively reached to 1000mg/L and 70mg/L, removal rate of COD in one and two stage of IC anaerobic reactor respectively reached to 85% and 75% , the removal rate of NH4+-N were respectively reached to 22% and 17%; Hydraulic retention time (HRT) of SBAR reactor is 480min, volume loading of COD is 4.0Kg COD/ (m3.d), the removal rate of the influent COD and NH4+-N were stable at 92% and 79%, pH value of The effluent is up to 7.0. The final concentration of the COD and NH4+-N in effluent of this process is less than 100 mg/L and 10 mg/L respectively. All effluent number can meet the requirement of Discharge standard of water pollutants for fermentation alcohol and distilled spirits industry (GB27631-2011). |
查看全文
查看/发表评论 下载PDF阅读器 |
关闭 |